Clarke ENCORE MAX Manuel de l'opérateur

CLARKE 1-1ENCORE MAXAll directions given in this book are as seen from the operator's position at the rear of the machine.For new books

1-10 CLARK

CLARKE 1-11ENCORE MAXSAFETY PRECAUTIONSELECTRICAL HAZARD - Shocks cancause serious personal injuryDisconnect battery before workingin this a

1-12 CLARK

CLARKE 1-13ENCORE MAX• Be careful when operating the machine on a ramp or incline. Do not operate machine on incline greaterthan 8° or longe

1-14 CLARK

CLARKE 1-15ENCORE MAXWIDTHEncore Max (34”) Machine 33.5” (85 cm)Brush Housings 38.0” (96.5 cm)Squeegee 42.0” (106.7cm)Encore Max (38”) Machi

1-16 CLARK

CLARKE 1-17ENCORE MAXYour Encore Max battery machine has been shipped complete, but do not attempt to operate without readingthe following i

1-18 CLARK

CLARKE 1-19ENCORE MAXREMOVE BATTERYFROM BOXUNPACKING BATTERYThe batteries are shipped separately in six boxes as shown in figure 5. Open the

1-2 CLARKE

1-20 CLARK

CLARKE 1-21ENCORE MAXCONTROLS123457891061213111. Solution Flow Knob2. Brush Switch3. Low Solution Light (Left) High Recovery Light (Right)4.

1-22 CLARK

CLARKE 1-23ENCORE MAXBRUSH SWITCHSCRUBPRESSURESWITCHSCRUB BRUSH SWITCHThe scrub brush switch is located on the left side of the console to r

1-24 CLARK

CLARKE 1-25ENCORE MAXSOLUTION FLOWKNOBLOW SOLUTIONLIGHTHIGH RECOVERYLIGHTSOLUTION FLOW ONSOLUTION FLOW CONTROL KNOBThe solution flow control

1-26 CLARK

CLARKE 1-27ENCORE MAXPEDAL LOCKBRAKE PEDALSECONDARY PARKING BRAKE (OPTION)The machine is equipped with an electrically actuated mechanical p

1-28 CLARK

CLARKE 1-29ENCORE MAXSEAT SWITCHSEAT ADJUSTMENT LEVERSEAT ADJUSTMENT LEVERThis lever is located on front to the seat to the left allowing th

CLARKE 1-3ENCORE MAXINDEXCCONTROLS 21DDECIMAL-METRIC CONVERSION TABLE 5DISCLAIMER 4EELECTRICAL SCHEMATIC 53HHARDWARE ABBREVIATIONS 6HYD

1-30 CLARK

CLARKE 1-31ENCORE MAXDRAIN HOSESQUEEGEE HOSESQUEEGEEBRUSHESTO BEGIN THE CLEANING OPERATION1. Lower brushes to the desired position.SCRUB DEC

1-32 CLARK

CLARKE 1-33ENCORE MAXSOLUTIONTANKRECOVERYTANKSOLUTIONCONTROLVALVESCRUBBRUSHSQUEEGEEFLOOR CONTACTSTRAINERSOLUTIONPUMPSTRAINERESP OPERATING MO

1-34 CLARK

CLARKE 1-35ENCORE MAXDRAIN HOSEDRAIN HOSE PLUGDRAIN HOSEDRAIN HOSE PLUGDRAINING RECOVERY TANKTO DRAIN RECOVERY TANKThe drain hose for the re

1-36 CLARK

CLARKE 1-37ENCORE MAXOPERATING INSTRUCTIONSInspect the rear and side squeegee blades for wear. If the wiping edge has become rounded, remove

1-38 CLARK

CLARKE 1-39ENCORE MAXWARNINGBATTERYCOVERCOULD CLOSE UNEXPECTEDLYANDCAUSEPERSONAL INJURY.EngageSafetyLatch Before Working in this area.WARNIN

1-4 CLARKE

1-40 CLARK

CLARKE 1-41ENCORE MAX++++++++--------BATTERYCHARGERSAFETY LATCHCONNECT BATTERIESBATTERY CHARGING INSTRUCTIONWhen the batteries are disconnec

1-42 CLARK

CLARKE 1-43ENCORE MAXBATTERY REMOVALWhen removing batteries1. Lift the seat cover making sure the safety latch is secure in the notch.2. Rem

1-44 CLARK

CLARKE 1-45ENCORE MAXADJUSTMENTCASTORSSQUEEGEE CASTER WHEEL ADJUSTMENTAdjust if squeegee leaves water on floor. The wheels must be 3/16"

1-46 CLARK

CLARKE 1-47ENCORE MAXLOOSEN NUTTO ADJUST BELTSIDE BROOM BELTPULL FORWARD TO TIGHTEN BELTSide Broom Belt1. Check belt tension adjustment as s

1-48 CLARK

CLARKE 1-49ENCORE MAXFUSESFuse 1 10 Amp Scrub Deck Actuator FuseFuse 2 10 Amp Scrub Deck Actuator FuseFuse 3 10 Amp Squeegee Actuator FuseFu

CLARKE 1-5ENCORE MAXFRACTION FRACTIONDECIMAL DECIMALMILLIMETER MILLIMETERC-2001/9907DECIMAL-METRIC CONVERSIONTABLE

1-50 CLARK

CLARKE 1-51ENCORE MAXTROUBLE SHOOTINGMachine moves slow or erratically. 1. Battery charge low. 2. Brakes dragging. 3. Loose connection at

1-52 CLARK

CLARKE 1-53ENCORE MAXELECTRICAL SCHEMATICPG 53REMOVE & INSERT 11 X 17

1-54 CLARK

CLARKE 1-55ENCORE MAXNOTES

1-56 CLARK

CLARKE 1-57ENCORE MAXWIRE HARNESS ROUTING PG 57Ref# 71716-3REMOVE & INSERT 11 X 17

1-58 CLARK

CLARKE 1-59ENCORE MAXCODE PGDT TECHNICAL PROBABLE CAUSE SERVICE ACTION DESCRIPTION000301000204070

1-6 CLARKE

1-60 CLARK

CLARKE 1-61ENCORE MAXTRIO SCRUBBER DIAGNOSTIC CODES CON’T.7601760276037604770077017702770378007801780279007901Soft brush currentfoldbackSoft

CLARKE 1-7ENCORE MAXSAE - Grade 5SAE - Grade 8ScrewSizeGrade5PlatedGrade8Plated410HStainlessBrassTypeF&T&BTTypeB, AB*6*8*10*1/45/163

1-8 CLARKE

CLARKE 1-9ENCORE MAXScrub Brush Down Heavy PressureSqueegee Down & Vacuum OnSqueegee Up & Vacuum OnSolution Tank LowSolution Flow Co