Clarke CR 28 Boost Manuel de l'opérateur

Operator’s ManualLibro de InstruccionesManuel d’utilisationREAD THIS BOOKLEA ESTE MANUALLISEZ CE MANUEL ENESFREnglish (1 - 24)Español (... - ...)Fra

ENGLISHOperator’s Manual - CR 28 BOOST®9ACCESSORIES/OPTIONSIn addition to the standard components, the machine can be equipped with the following acce

ENGLISH10Operator’s Manual - CR 28 BOOST®WIRING DIAGRAMKeyBAT 24 V batteriesBE Flashing lightBRK Electromagnetic brakeBZ1 Reverse gear warning buzzer/

ENGLISHOperator’s Manual - CR 28 BOOST®11USEWARNING!On some points of the machine there are some adhesive plates indicating:DANGER –WARNING –CAUTION –

ENGLISH12Operator’s Manual - CR 28 BOOST®BATTERY INSTALLATION AND BATTERY TYPE SETTING (WET OR GEL)According to the type of batteries (WET or GEL), se

ENGLISHOperator’s Manual - CR 28 BOOST®13BEFORE START-UPWARNING!At every machine start-up, check that, between the deck (4 or 5) and the machine or be

ENGLISH14Operator’s Manual - CR 28 BOOST®Squeegee installationInstall the squeegee (12) and fasten it with the handwheels (15), then connect the sucti

ENGLISHOperator’s Manual - CR 28 BOOST®15MACHINE OPERATION (SCRUBBING/DRYING)Start the machine as shown in the previous paragraph.1. If necessary, adj

ENGLISH16Operator’s Manual - CR 28 BOOST®Battery discharge during operationUntil the green warning light (37a) stays on, the batteries allow the machi

ENGLISHOperator’s Manual - CR 28 BOOST®17MACHINE LONG INACTIVITYIf the machine is not going to be used for more than 30 days, proceed as follows:1. Pe

ENGLISH18Operator’s Manual - CR 28 BOOST®SQUEEGEE CLEANINGNOTEThe squeegee must be clean and its blades must be in good conditions in order to get a g

ENGLISHOperator’s Manual - CR 28 BOOST®1TABLE OF CONTENTSINTRODUCTION ...

ENGLISHOperator’s Manual - CR 28 BOOST®19BRUSH CLEANINGCAUTION!It is advisable to use protective gloves when cleaning the brush because there may be c

ENGLISH20Operator’s Manual - CR 28 BOOST®SIDE SKIRT CHECK AND REPLACEMENTCheckDrive the machine on a level fl oor.1. Turn the ignition key (41) to “0”.

ENGLISHOperator’s Manual - CR 28 BOOST®21VACUUM SYSTEM MOTOR FILTER CLEANINGDrive the machine to the appointed disposal area and drain the water from

ENGLISH22Operator’s Manual - CR 28 BOOST®BATTERY CHARGINGNOTECharge the batteries when the yellow (37b) or red warning light (37c) turns on, or when fi

ENGLISHOperator’s Manual - CR 28 BOOST®23FUSE CHECK/REPLACEMENTTurn the ignition key (41) to “0”.1. Remove the nuts (E, Fig. 7), then remove the cover

ENGLISH24Operator’s Manual - CR 28 BOOST®TROUBLESHOOTINGTROUBLE POSSIBLE CAUSE ACTIONThe motors do not work; no warning light turns on.The battery con

Form No. 9097861000 - 09/2008 [ ] = Not shown * = optional     #=ModieditemNo.orNewitemNo.Parts List

74Parts List - CR 28 BOOST® GENERAL VIEW Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®75 GENERAL VIEW - 09/2008Ref. Part No. Description Qty1 145 1129 000 WASHER 16X6 62 145 1894 000 SCREW M6X30 63# SQUEEGEE SYS

76Parts List - CR 28 BOOST® TANKS ASSEMBLY Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

ENGLISH2Operator’s Manual - CR 28 BOOST®INTRODUCTIONNOTEThe numbers in brackets refer to the components shown in Machine Description chapter.MANUAL PU

Parts List - CR 28 BOOST®77 TANKS ASSEMBLY - 09/2008Ref. Part No. Description Qty1 909 6245 000 FRESH WATER TANK 12 909 6401 000 HARDWARE WATER TANK K

78Parts List - CR 28 BOOST® RECOVERY TANK Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®79 RECOVERY TANK - 09/2008Ref. Part No. Description Qty1 9097340000 RECOVERY TANK BLUE 12 909 6489 000 GASKET VACUUM MOTOR 13

80Parts List - CR 28 BOOST® CHASSIS SYSTEM Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®81 CHASSIS SYSTEMRef. Part No. Description Qty1 9097206000 SUPPORT ROLLER BUMPER 12 909 6065 000 CHASSIS 13 L08812248 BUMPER

82Parts List - CR 28 BOOST® FRONT WHEEL ASSEMBLY Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®83 FRONT WHEEL ASSEMBLYRef. Part No. Description Qty1 L08600669 SPLIT PIN 22 L08603041 SCREW M5X10 UNI7985 13 33004605 SREW H

84Parts List - CR 28 BOOST® MOTOR DRIVE WHEEL Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®85 MOTOR DRIVE WHEELRef. Part No. Description Qty1 9096935000 TYRE WHEEL 12 9096966000 ELECTROMAGNETIC BRAKE 13 9096959000 BA

86Parts List - CR 28 BOOST® STEERING SYSTEM - 09/2008 Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

ENGLISHOperator’s Manual - CR 28 BOOST®3UNPACKING/DELIVERYTo unpack the machine carefully follow the instructions on the packing.Upon delivery careful

Parts List - CR 28 BOOST®87 STEERING SYSTEM - 09/2008Ref. Part No. Description Qty1 33005691 NUT HEX M5 UNI5588 22 33005842 WASHER M8 UNI1751B 83 145

88Parts List - CR 28 BOOST® CONTROL PANEL ASSEMBLY Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®89 CONTROL PANEL ASSEMBLYRef. Part No. Description Qty1 33005601 NUT HEX SELFLOCK M3 32 146 2888 000 KEY SWITCH 13 146 2655 0

90Parts List - CR 28 BOOST® PEDAL ASSEMBLY Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®91 PEDAL ASSEMBLYRef. Part No. Description Qty1 33005604 NUT SELF L. M6 UNI7474 22 145 2473 000 ROD TENSION M6X32 13 145 3665

92Parts List - CR 28 BOOST® FOOTBOARD ASSEMBLY Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®93 FOOTBOARD ASSEMBLY - 09/2008Ref. Part No. Description Qty1 9097392000 FOOTBOARD 12# PEDAL ASSEMBLY (SEE PAGE 90) 13 145 46

94Parts List - CR 28 BOOST® SOLUTION SYSTEM Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®95 SOLUTION SYSTEMRef. Part No. Description Qty1 909 6389 000 CAP KIT 12 909 6390 000 PRESSURE SENSOR HOSE KIT 13 909 6391

96Parts List - CR 28 BOOST® SQUEEGEE SYSTEMS Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

ENGLISH4Operator’s Manual - CR 28 BOOST®WARNING!Carefully read all the instructions before performing any maintenance/repair procedure. –Before using

Parts List - CR 28 BOOST®97 SQUEEGEE SYSTEMS - 09/2008Ref. Part No. Description Qty1# 9098022000 KIT SQUEEGEE 34” 12 909 6397 000 SQUEEGEE SYSTEM HARD

98Parts List - CR 28 BOOST® BOOST® HEAD ASM - 09/2008 Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®99 BOOST® HEAD ASM - 09/2008Ref. Part No. Description Qty1# 40262A CAM LOCKING 22 920365 NUT 1/2-13 NYLOCK 43# 80317A WASHER

100Parts List - CR 28 BOOST® DECK ASM. BOOST® Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®101 DECK ASM. BOOST® - 09/2008Ref. Part No. Description Qty1 782002 CLAMP, MANIFOLD 32 925589 PIN, ROLL 13 962098 SCREW, 1/4-

102Parts List - CR 28 BOOST® HEAD ASSEMBLY - 09/2008 Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®103 HEAD ASSEMBLY - 09/2008Ref. Part No. Description Qty1# 962929 SCREW, 10-32 X 1/2” PH 52# 38032L RH OUTER SQUEEGEE 13 6194

104Parts List - CR 28 BOOST® SEAT ASSEMBLY Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®105 SEAT ASSEMBLY - 09/2008Ref. Part No. Description Qty1 909 6244 000 SEAT SUPPORT 12 909 5897 000 SEAT 13 909 6098 000 CAP

106Parts List - CR 28 BOOST® BRUSH DECK LIFTING SYSTEM - 09/2008 Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

ENGLISHOperator’s Manual - CR 28 BOOST®5SYMBOLS SHOWN ON THE MACHINEWARNING!Carefully read all instructions before performing any procedure on the mac

Parts List - CR 28 BOOST®107 BRUSH DECK LIFTING SYSTEM - 09/2008Ref. Part No. Description Qty1 909 6385 000 LEVER KIT 12 909 5637 000 SPRING GAS 13 9

108Parts List - CR 28 BOOST® ELECTRICAL COMPONENTS - 09/2008 Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®109 ELECTRICAL COMPONENTS - 09/2008Ref. Part No. Description Qty1 145 8046 000 FUSE CARRIER 12 146 0659 000 FUSE CARRIER, MAX

110Parts List - CR 28 BOOST® ACCESSORIES Order Parts Here: www.ivie-ent.com/parts Ph:(918)254-5161

Parts List - CR 28 BOOST®111 ACCESSORIESRef. Part No. Description Qty1* 146 2692 000BEACON FLASHING ON SUPPORT KIT1[3] 146 2693 000 INSTALLATION INSTR

112Parts List - CR 28 BOOST® RECOMMENDED SPARE PARTS RECOVERY TANK909 6489 000 GASKET VACUUM MOTOR 19097466000 MOTOR VACUUM KIT 19097399000 FILTER 19

Parts List - CR 28 BOOST®113 RECOMMENDED SPARE PARTS Part No. Description QtySQUEEGEE SYSTEMS909 6223 000 HANDWHEEL M8X451909 6394 000 SQUEEGEE LATCH

ENGLISH6Operator’s Manual - CR 28 BOOST®MACHINE DESCRIPTIONMACHINE STRUCTURESteering wheel inclination control lever1. Steering wheel2. Drive pedal3.

ENGLISHOperator’s Manual - CR 28 BOOST®7CONTROL PANELControl panel31. Emergency push-button32. Horn33. Scrub and vacuum activation button34. Extra pre

ENGLISH8Operator’s Manual - CR 28 BOOST®VIEW UNDER TANK COVERSRecovery tank cover51. Recovery tank cover gasket52. Recovery water vacuum duct53. Vacuu